Broil King Crown Crown™ 500 Freestanding Smart Wood Pellet Grill Owner's Manual - Manuel (Page 2)

SAFTEY INSTALLATION
2
Your new Broil King ® Pellet Grill is a safe, convenient appliance
when assembled and used properly. As with all pellet fuel-burning
products, however, certain safeguards must be observed. Failure
to follow these safeguards may result in serious injury or damage.
If you have questions concerning assembly or operation, consult
your dealer, or our direct customer service line at 1-800-265-2150.
/ [email protected]
• Please read this entire manual before installation and use of
this pellet-burning appliance. Failure to follow these
instructions could result in property damage, bodily injury, or
even death.
• Contact local building or fire officials about restrictions and
installation inspection requirements in your area.
• Save these instructions for future reference.
DANGER
• This grill is designed for OUTDOOR USE ONLY . If used
indoors, toxic fumes will accumulate and cause serious bodily
injury or death. Follow these guidelines to prevent this
colorless, odorless gas from poisoning you, your family, or
others.
• Know the symptoms of carbon monoxide poisoning: headache,
dizziness, weakness, nausea, vomiting, sleepiness, and
confusion. Carbon monoxide reduces the blood’s ability to
carry oxygen. Low blood oxygen levels can result in loss of
consciousness and death.
• See a doctor if you or others develop cold- or flu-like
symptoms while cooking or in the vicinity of this appliance.
Carbon monoxide poisoning, which can easily be mistaken for
a cold or flu, is often detected too late.
• Alcohol consumption and drug use increase the effects of
carbon monoxide poisoning.
• Carbon monoxide is especially toxic to mother and child during
pregnancy, infants, the elderly, smokers, and people with
blood or circulatory system problems, such as anemia or heart
disease.
• Never use gasoline, gasoline-type lantern fuel, kerosene,
charcoal lighter fluid, or flammable liquids with this appliance
to start or maintain a fire.
• Never store any combustible material close or under the
appliance
• Do not leave children or pets unattended near a hot grill.
• Do not attempt to move a hot grill.
• Do not use unless grill is fully assembled and all parts are in
place.
• Do not remove ashes until all pellet fuel is completely burned
out and fully extinguished.
• Do not use grill in high winds.
• If a flare up occurs, do not use water to put out fire. Turn OFF.
Unplug power cord and wait for grill to cool.
ELECTRICAL CAUTION
• This appliance uses an external electrical power source and
must be electrically grounded in accordance with local codes.
In the absence of local codes, the following standards apply:
(U.S.A) ANSI/NFPA No. 70-Latest Edition and (Canada) CSA
C22.1 Canadian Electrical Code.
• Do not operate unit if the plug receptacle is damaged.
• Do not cut or remove the grounding prong from the plug.
• Keep the electrical supply cord away from any heated
surfaces.
PROPOSITION 65 WARNING
Combustion (burning) of this product, produces carbon monoxide
and other substances known by the State of California to cause
cancer and birth defects or other reproductive harm. For more
information go to www.P65warnings.ca.gov/product
A MAJOR CAUSE OF FIRES IS
FAILURE TO MAINTAIN
REQUIRED CLEARANCES (AIR
SPACES) TO COMBUSTIBLE
MATERIALS. IT IS OF UTMOST
IMPORTANCE THAT THIS
PRODUCT BE INSTALLED ONLY
IN ACCORDANCE WITH THESE
INSTRUCTIONS.
• The appliance must be installed away from combustible
surfaces by at least 30inch / 76cm from each side, and 30inch
/ 76cm from the rear. There must be 40inch / 100 cm of space
between the top of the appliance and any over head
construction.
• Never install the appliance underneath plants, trees or foliage.
• WARNING: Always install the appliance on a non-combustible
surface.
• WARNING: Always install the appliance on a level surface and
keep the appliance level.
• This appliance is for OUTDOOR USE ONLY, do not operate in
garage, shed, balcony or other such enclosed areas.
• DO NOT restrict the flow of air to the appliance.
• Keep the area surrounding the appliance free of combustible
materials, pellets, gasoline, and all flammable liquids and
vapors.
• This appliance is not intended to be installed in, or on,
recreational vehicles and/or boats.
• Do not use or install accessories that change or modify the
pellet hopper, auger, burn pot or exhaust systems.
WARNING
• Preheat grill with lid open for first 10 minutes or until white
smoke turns clear.
• Never touch the pellet tray, ash clean out or cooking grate to
see if they are hot.
• Use barbecue mitts or hot pads to protect hands while cooking
or adjusting top damper.
• Use proper barbecuing tools with long, heat-resistant handles.
• Only use food grade wood pellets. Broil King ® Premium Grilling
Pellets are recommended
• Always store wood pellets in a dry location, away from heat-
producing appliances and other fuel containers.
• To extinguish the pellets, turn off the pellet digital control and
close the damper completely. Do not use water.