Napoleon Fireplaces High Definition 81 - HD81 - Manuel (Page 2)

W415-0687 / G / 08.26.13
2
EN
NOTE: Changes, other than editorial, are denoted by a vertical line in the margin.
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.2 GENERAL INSTRUCTIONS 5
2.3 GENERAL INFORMATION 6
2.4 RATING PLATE INFORMATION 7
3.0 VENTING 8
3.1 VENTING LENGTHS AND COMPONENTS 8
3.2 TYPICAL VENT INSTALLATION 9
3.3 VENT TERMINAL CLEARANCES 10
3.4 VENT APPLICATION FLOW CHART 11
3.5 DEFINITIONS 11
3.6 ELBOW VENT LENGTH VALUES 11
3.7 HORIZONTAL TERMINATION 12
3.8 VERTICAL TERMINATION 14
4.0 INSTALLATION 16
4.1 WALL AND CEILING PROTECTION 16
4.1.1 HORIZONTAL INSTALLATION 17
4.1.2 VERTICAL INSTALLATION 17
4.2 USING FLEXIBLE VENT COMPONENTS 18
4.2.1 HORIZONTAL AIR TERMINAL INSTALLATION 18
4.2.2 VERTICAL AIR TERMINAL INSTALLATION 19
4.2.3 APPLIANCE VENT CONNECTION 20
4.3 MOBILE HOME INSTALLATION 20
4.4 GAS INSTALLATION 21
5.0 FRAMING 22
5.1 MINIMUM CLEARANCES TO COMBUSTIBLES 24
5.2 HEARTH EXTENSION 24
5.3 STEEL STUD FRAMING KIT 25
5.3.1 INSIDE FRAME ASSEMBLY 25
5.3.2 ATTACH SIDE STUDS (LEGS) 26
5.3.3 ATTACH THE ASSEMBLED FRAME TO THE APPLIANCE 26
5.3.4 INSTALL CONCRETE BOARD SIDE AND CENTER PANELS 27
5.3.5 STEEL FRAMING KIT SIDE TWO 27
5.4 MINIMUM CLEARANCE TO COMBUSTIBLE ENCLOSURES 28
5.5 MINIMUM MANTEL CLEARANCES 30
6.0 FINISHING 30
6.1 DOOR REMOVAL / INSTALLATION 31
6.2 BURNER INSTALLATION 31
6.3 NON-COMBUSTIBLE FACING MATERIAL 32
7.0 ELECTRICAL INFORMATION 33
7.1 HARD WIRING CONNECTION 33
7.2 OPTIONAL BLOWER INSTALLATION 33
7.3 SCHEMATIC 33
7.4 RECEPTACLE WIRING DIAGRAM 34
7.5 REMOTE RECEIVER INSTALLATION 34
8.0 OPERATION 35
8.1 GENERAL TRANSMITTER LAYOUT 35
8.2 APPLIANCE OPERATION 35
8.3 HAND-HELD REMOTE OPERATIONS 35
8.4 TEMPERATURE DISPLAY 36
8.5 FLAME HEIGHT 36
8.6 FAN SPEED 36
8.7 CHILDPROOF FUNCTION 37
8.8 NIGHT LIGHT™ 37
8.9 SPLIT FLOW VALVE 37
8.10 LOW BATTERY / MANUAL BYPASS 38
8.11 IN THE EVENT OF A POWER FAILURE 38
8.12 CONTROL MODULE 38
8.13 ANTI-CONDENSATION CONTROL SWITCH 39
8.14 AIR CONTROL 39
9.0 OPERATING INSTRUCTIONS 40
10.0 ADJUSTMENT 41
10.1 PILOT BURNER ADJUSTMENT 41
10.2 FLAME CHARACTERISTICS 41
10.3 RESTRICTING VERTICAL VENTS 41