BE Pressure supply 125,000 BTU LPG Forced Air Heater HL25F Manuel d'utilisation

Page 3

Advertising

Never Leave Heater UNatteNded

wHiLe bUrNiNg, coNNected to a

power soUrce or wHiLe

coNNected to a fUeL soUrce.

This is a direct-fired, forced-air construction heater for either

indoor or outdoor use. It’s intended use is primarily for the

temporary heating of buildings under construction, alteration or

repair. All of the products of combustion generated by this heater

are forced through the heater and released into the area being

heated. This heater operates at approximately 98%+ combustion

efficiency, but still produces small amounts of carbon monoxide.

Humans can tolerate small amounts of carbon monoxide for short

periods. Carbon monoxide can build up in a heated space, and

failure to provide adequate ventilation could result in poisoning or

death.

You must provide the propane gas and cylinder(s). Use this

heater only with a propane vapor withdrawal supply system.

Refer to Chapter 5 of the Standard for Storage and Handling of

Liquefied Petroleum Gas , ANSI/NFPA 58. Your local library or

fire department will have this booklet.

- Children should be kept away.

- Always maintain proper clearance from combustible materials.

Minimum clearance should be:

Sides - 24” Top - 36” Front - 72”

- Do not store or use gasoline or other flammable vapors and

liquids in the vicinity of this or any other appliance.

- An LP cylinder not connected for use shall not be stored in the

vicinity of this or any other appliance.

- Heater must be placed on level and solid footing.

- Never place anything, including clothes or other flammable items

on heater.

- Do not modify heater, or operate a heater that has been

modified.

- Adequate clearance for accessibility, combustion and ventilation

(air supply) must be maintained at all times when heater is operating.

- Service and repair should be performed by a qualified service

person. The heater should be inspected before each use, and at

least annually by a qualified person. More frequent cleaning may

be required as necessary. Do not service heater while hot or

operating.

- Never connect heater to an unregulated gas supply.

- This heater is equipped with a 3-prong (grounding) plug for your

protection against shock hazard and should be plugged directly

into a properly grounded three-prong receptacle.

- Use only the electrical/power cord specified. Electrical and

1. Remove all packing items applied to heater for shipment. Keep

plastic cover caps attached to inlet connector and hose/regulator

assembly for storage.

2. Remove all items from carton.

3. Check all items for shipping damage. If heater is damaged,

promptly inform dealer where you purchased the heater

grounding connection must comply with National Electrical

Code - ANSI/NFPA 70 (USA) and CSA C22.1 Canadian

Electrical Code, Part 1 (Canada).

- To prevent injury, always wear gloves when handling heater.

Never handle an operating or hot heater, as severe burns may

result.

- Use heater in accordance with all local codes. In the absence

of local codes, refer to The National Fuel Code, ANSI Z223.1.

- This heater is shipped from the factory for use with LP (propane)

gas only. Do not convert to any other gas. Installation must

conform to local codes, or in their absence, with the standard for

the Storage and Handling of Liquefied Petroleum Gases

ANSI/NFPA 58 and the Natural Gas and Propane Installation

Code 149.1.

- Use only the regulator and hose assembly provided with this

heater. Inspect the regulator/hose assembly prior to each use of

the heater. If there is excessive abrasion or wear, or if the hose

is cut, replace it with the proper assembly shown in the parts list,

prior to using the heater

- Gas supply connections should be checked by using a 50/50

soap and water solution. Never use a flame to check for gas

leaks.

- Locate LP cylinder at least 6 feet (10 ft. in Canada) from the

heater, and do not direct heater discharge towards the

LP cylinder unless it is at least 20 feet from the heater.

- The electrical connection and grounding must comply with the

National Electrical Code, ANSI/NFPA 70 and CSA C22.1

Canadian Electrical Code, Part 1 (Canada) Canadian Electrical

Code, Part 1. Use only a properly grounded three (3) prong

receptacle.

- Do not restrict air inlet or outlet areas of the heater.

Safety Information (continued)

The Propane (LP) gas pressure regulator and hose

assembly supplied with the heater must be used
without alteration

The hose assembly shall be pro tected from traffic,

building material and contact with hot surfaces

both during use and while in storage.

Not for use with ductwork.

Caution

WARNING

Model #s: PT-16-TTC (Single Burner),

PT-32-TTC (Double Burner),

PT-47-TTC (Triple Burner)

User’s Manual and

Operating Instructions

Propane

Tank Top Heaters

IMPORTANT:

Read and understand all of the direc-

tions in this manual before assembling, starting or servic-

ing the heater. Improper use of this heater can cause

serious injury. Keep this manual for future reference.

CONSUMER: Retain this manual for future reference.

Pinnacle Products International, Inc. 668 Stony Hill Road #302 Yardley, PA 19067 USA

Phone: 215-891-8460 Fax: 215-891-8461 Web: www.pinnacleint.com Email: [email protected]

Table of Contents

Safety Information.........................................................2-3

Product Identification........................................................3

Propane Supply................................................................3

Ventilation............................................................3

Assembly..........................................................................3

Connecting Heater to Cylinder..........................................4

Lighting Instructions..........................................................5

Maintenance and Storage.................................................6

Replacement Parts List.....................................................6

Exploded Parts Drawing...................................................7

Warranty...........................................................................8

201000016-12

Carbon Monoxide Hazard This heater produces carbon monoxide, which has no odor. Burning the

heater in an enclosed space can kill you. Never use the heater in enclosed spaces such as a tent, a

camper, any vehicle or recreational vehicle (RV), enclosed shelter, or any other enclosed areas.

Not for use in residential living areas or in non-adequately ventilated enclosed spaces. Never

bring or store a propane cylinder indoors.

WARNING

DANGER

OUTDOOR USE ONLY

S I G

C E

I E

T I F

CERTIFIED

FAILURE TO COMPLY WITH THE

PRECAUTIONS AND INSTRUCTIONS

PROVIDED WITH THIS HEATER, CAN

RESULT IN DEATH, SERIOUS BODILY

INJURY AND PROPERTY LOSS, OR

DAMAGE FROM THE HAZARDS OF FIRE,

EXPLOSION, BURN. ASPHYXIATION,

CARBON MONOXIDE POISONING AND / OR

ELECTRIC SHOCK.

ONLY PERSONS WHO CAN UNDERSTAND

AND FOLLOW THE INSTRUCTIONS

SHOULD USE OR SERVICE THIS HEATER.

IF YOU NEED ASSISTANCE OR HEATER

INFORMATION SUCH AS AN INSTRUCTION

MANUAL, LABELS, ETCETERA, CONTACT

THE MANUFACTURER.